Doctor Diesel, Features

Mixed Feelings on Diesel Brands

Share on facebook
Share on twitter
Share on linkedin

web01Some recent letters to you have been on the subject of unexplained variation of mpg figures. I too was perplexed by variations going back some 15 years. I concluded that, for my motoring style, supermarket fuels used by themselves i.e. no other fuel in the tank, resulted in a 10 to 12 per cent increase in consumption. However, if there was a mix with at least 50 per cent major oil company fuel, consumption figures were the same as if the major oil diesel was used by itself. This revelation came on a 700-mile journey in France six years ago when I set off with 100 per cent Esso fuel in the tank. With approximately half a tank remaining, we then filled up with Total and, although I was using the cruise control and continuing on the same motorway, fuel consumption immediately rose (i.e. the mpg fell) by some six per cent. Later that trip, as we gradually increased the Total concentration towards 100 per cent, the mpg figures returned to those that we had experienced with pure Esso. I’ve since concluded that mixing a major branded fuel with other major oil fuels always causes an increase of consumption, even if there is less than ten per cent of one of them. The label on the bottles of Millers diesel fuel treatment warns not to mix additives, and I suspect that each oil major adds their own particular cetane improver, and that these inhibit each other to the detriment of the diesel combustion, and hence increase the fuel consumption figures.
Malcolm Billings

I have personally found, particularly in relation to touring in France, that day-to-day mpg variations can be quite significant and suspect that this must be purely as a result of ambient conditions, if the nature of the roads changes little and it is the same fuel in the tank. I first experienced this strange variation back around 2004 to 2005, when I was touring France in an Audi A2 1.4 TDI 90. Variations of the order of three to four mpg in around 50 to 55mpg were typical. We know that ambient temperature has some ill-effects, if it rises sufficiently that the intercooler can’t do its work properly, and the charge air density drops. Wind level or direction is usually noticeable, and I don’t think this was an effect on the occasions that I am quoting. That really leaves only ambient air pressure, in that lower pressure means lower density and therefore less oxygen available to burn the fuel. But diesels run with excess air and therefore there’s generally no shortage of oxygen. Whether the air density effect operates through the MAF (mass air flow) meter to change any key operating conditions and fuel injection settings I do not know. Then there is humidity, which might just be the answer – and, as we know, there are sometimes gains to be had from water injection in both diesel and petrol engines, although they don’t seem to be exploited much.

So the day-to-day variations of mpg in one car, and on the same fuel, remain very much a mystery to me, and I do think that they could cloud the sort of mpg variations that you are quoting. But I don’t think it would be incorrect to suggest that some engines “like” some fuels, and not others. I ran a Rover 75 2.0 CDT back in 2001 to 2003, and the only fuel that it seemed not to like was Morrison’s diesel, on which it ran so badly that I thought that I had an engine problem. But a double dose of Millers sorted it out, although I have never bought Morrison’s diesel since.
You also suggest that the variations that you have noted might be related to cetane values of the fuel. This could be true, but all EC cars are produced to run on the lowest cetane number allowed by the EC specifications ­– CN 51 – and most are found on testing to be well above the lower limit. Here again though, in relation to engines liking one fuel and not another, I would suggest that some engines have a different optimum efficiency cetane number from others. You refer in particular to Esso vs BP, and I am presuming that you refer to standard BP diesel, and not the outrageously overpriced BP Ultimate. With regard to Esso, if you dig around you will see that they specifically advertise their super grade diesel as (simply) having double the additive package that the standard stuff has. So in many ways the whole issue is a bit fuzzy, and I wish there were more specific answers and conclusions available. But it seems that one man’s or car’s ideal fuel is not necessarily another’s. With the complexity of multi-pulse injection these days, I guess that’s no surprise. In fact I can even imagine that a Ford 1.6-litre TDCi engine and a Peugeot 1.6-litre HDi unit, which essentially are the same thing, may well not respond identically to different fuels.
Doc Diesel

4 Responses

  1. According to Volvo’s top engine man, though all diesel engines recently sold within the EC will run on the lowest Cetane diesel and lowest Ron petrol, they are actually calibrated and optimised for the very best diesel and petrol for the ECDC tests, for the obvious reason that it gives them the best chance of a low CO2 and fewer litres per 100 kilometres. The key to getting better fuel economy is more torque at low revs without any adjustment to fuelling, because that allows you to change up earlier for the same performance and, in general, the lower the revs you use, the better economy. That all makes sense to me, but maybe I misinterpreted the man from Volvo.

    HJ

  2. Hi I am a new diesel car owner Hyundai i30.Just a quick question about the possible problem of DPF is there a particular driving style required or just a quick blast down the motorway once a week ok Thanks

  3. Hi Mick

    Just give the car some regular exercise from time to time and I’m sure you won’t suffer any problems. If the DPF light does come on, make sure you read the owner’s handbook and take the necessary action.

Leave a Reply to Honest John Cancel reply

Your email address will not be published. Required fields are marked *

related

SUBSCRIBE
today

and save over 40%

polls